乐仑彩票

咨询服务热线:1596503895715965038957   0536-6110289

热门关键词搜索: 蔬菜烘干机脱水蔬菜干燥机 蔬菜烘干设备 干燥设备

脱水蔬菜干燥机的工作过程

返回列表来源:诸城市博汇机械乐仑彩票 网址:www.sz-jlcsa.com/发布日期 2017-07-10 浏览:

  依据所需处理物质的特点,还有用户的要求,可以为用户设计制作出适用,品质好的机器。并且它可以调节空气量、加热温度还有这个加料速度,当然整个工作的过程是非常复杂的,这是为了确保获得质量好的产品。脱水蔬菜干燥机工作过程:

  According to the characteristics of the material to be processed and the requirements of the user, the machine can be designed and made to be suitable and good quality for the user. And it can adjust the amount of air, heating temperature, and the feeding rate, of course, the whole process is very complex, this is to ensure that the quality of products obtained. Working process of dehydrated vegetable drier:

  料斗中的物料由加料器均匀地铺在不锈钢丝网上,由传动电机带动网在干燥箱内匀速移动。干燥段由若干单元组成,热风在两个或两个(或几个)单元内横向循环,空气由风机进入,通过换热器加热,热空气穿过物料民物料热交换,进入下腔,然后流向下一单元,降温后的热空气再经换热器进行二次加热,热空气穿透网带与物料再次热交换,湿热空气由排湿风机排出,完成干燥,每台干燥机单元数可根据物料的特性、工艺要求选取。

  The material in the hopper by the feeder evenly in the stainless steel wire net, mobile network in uniform drying box is driven by the drive motor. The drying section is composed of several units, the hot air in the two or two (or more) unit transverse circulation, air from the fan enters through the heat exchanger heating, hot air passes through the material feeding rumors heat exchange, then flows into the vena, a unit of hot air cooling after the heat exchanger two heating, hot air through heat exchange and mesh belt material again, wet and hot air from the fan discharge, drying each dryer unit number according to the material characteristics and process requirements of selection.

  应用:该干燥机是成批生产用的连续式干燥设备,用于透气性较好的片状、条状、颗粒状物料的干燥,对于脱水蔬菜、中药饮片等含水率高、而物料温度不允许高的物料尤为合适,该系列干燥机具有干燥速度快、蒸发强度高、产品质量好的优点,对脱水滤饼类的膏状物料,需经造粒制成棒状后亦可干燥。同时脱水蔬菜干燥机的热循环风能起到处理内部温度的作用,并且这个风量、风压各个部位相同。对产品干燥效果有保证,这个设计还能起到回收干燥机内部余热再次利用,大大提高热效率利用。

  Application: the dryer is a continuous drying device used for ventilating, sheet, strip, good dry granular materials for water, dehydrated vegetables, Chinese herbal medicine and other high rate, but the material high temperature is not allowed. Particularly suitable for the materials, the machine has the advantages of fast drying, evaporation, high strength products good quality, paste material of dehydrated cake, be made of rod through granulation after drying can. At the same time, the thermal cycling wind energy of the dehydrated vegetable dryer plays a role in the internal temperature treatment, and the air volume and the air pressure are the same. To ensure the drying effect of the product, the design can also be used to recover the internal heat of the dryer again, and greatly improve the thermal efficiency.

推荐阅读

网站声明:

本站部分素材搜集来源网络,如内容有侵权,请联系我司立即删除!本站内容按照相关法律法规进行编写;如有不当请联系我司立即删除!

服务热线

159-6503-8957

在线客服
开元棋牌APP 翡翠棋牌平台 456棋牌游戏中心 555棋牌游戏 宝乐彩票平台 555棋牌游戏官网 555棋牌游戏 京都棋牌 天天乐棋牌游戏下载 456棋牌